Kia Sportage>> Systems of an electric equipment of the engine

Systems of an electric equipment of the engine

Specifications

Separate characteristics are resulted also in the text of the head and in case of compulsion of their performance are allocated by a bold type.

System of ignition of the petrol engine

Type Electronic system of direct ignition (DIS) with the single spark, functioning under control of ECM, guided by indications of gauges of positions cranked (CKP) and distributive (CMP) shaft
Installation of a corner of an advancing of ignition 4 2 before ВМТ (under control of ECM, to adjustment is not subject)
Ignition order 1-3-4-2
Ignition coils
  • Type
Two dual bobbin modules (on one on two cylinders)
  • Pressure of a food of the coil (taking into account a ballast), In
12.0
  • Resistance of a primary winding, Ohm
0.45 0.55
  • Resistance of a secondary winding, clod
13 15
ВВ wires
  • Specific resistance, clod/m
16
Spark plugs
  • Type
    • NGK
BKR6E-11
    • Bosch
FR7DCX
    • Champion
RC7YC4
    • Beru
14FR-7DUX
    • Autolite
APP3923
Interelectrode backlash (all manufacturers), mm 1.1

System of simplification of cold start of the diesel engine

Duration of phases of preheat and postheat The Section System of simplification of cold start of the diesel engine see
Protective switching-off of the relay of candles накаливания The Section System of simplification of cold start of the diesel engine see
Resistance of the relay of candles накаливания (the Section Check of the relay of candles накаливания see), the Ohm 13

Charge system

The storage battery
  • Electrolit density at 25С (all models), kg/dm3
    • Rating value
1.280
    • Limiting admissible difference between banks
0.04
  • Nominal target pressure, In (grounding on a negative pole)
12
  • The capacitor characteristic (at the rate on 5 hours), Ach
    • Petrol models
60
    • Diesel models
68
The generator
  • Type (all models)
Alternating current
  • The target characteristic, В-А
    • Petrol models
12.-70
    • Diesel models
12-60
  • Regulator type (all models)
Transistor, it is built in the bobbin module
  • Nominal frequency of rotation, rpm
    • Petrol models
Data are absent
    • Diesel models
5000
  • Working range of turns, mines-1
    • Petrol models
Data are absent
    • Diesel models
1000 11000
  • Quantity of poles
    • Petrol models
Data are absent
    • Diesel models
12
The vacuum pump (diesel models)
  • Depth of depression, mm hg
    • At frequency of rotation of the generator of 1500 rpm, later 20 seconds
Not less than 440
    • At frequency of rotation of the generator of 3000 rpm, later 20 seconds
Not less than 580
  • Length шиберных shovels, mm
13.0 13.5
  • Internal diameter of a casing, mm
57.0 57.1

Start system

Type of a drive of a cranked shaft
  • Petrol models
    • Models with Manual transmission
Безредукторный
      • Models with АТ
Редукторный
  • Diesel models
Безредукторный
The maximum current strength at проворачивании the engine, And
  • Petrol models
130 158
  • Diesel models
Data are absent
Starter
  • Target capacity, kw
    • Petrol models
      • Models with Manual transmission
0.9
      • Models with АТ
1.2
    • Diesel models
2.0
  • Length of brushes, mm
    • Rating value
      • Petrol models
17
      • Diesel models
18
    • Limiting admissible value
      • Petrol models
11.5
      • Diesel models
11
Developed щеточной a spring effort (all models), Н 8.8

Size of palpation of anchor assemblage (all models)
  • Rating value
0.05
  • Limiting admissible value
0.4
Проточка a collector (all models)
  • The minimum admissible diameter, mm
31

Depth of a notch, mm
  • Rating value
0.02 0.03
  • Limiting admissible value
0.2

Working backlash of a gear wheel (petrol models), mm
0.5
Axial люфт gear wheels (diesel models)

Working backlash of a gear wheel of a starter (petrol models)

1 — a gear wheel Shaft
2 — Axial люфт
3 — the Lock ring
4 — the Washer

5 — a washer Arm
6 — the Adjusting washer
7 — Reduktsionnaja a gear wheel

Efforts of a tightening of carving connections, Nanometer

Efforts of a tightening of separate elements of fixture can be resulted directly in the text of sections where they are allocated by a bold type.

Petrol models

Bolts of fastening of bobbin assemblages 19 25
Spark plugs 25 30
Bolts of fastening of a starter and its basic arm 37 54
Plug nut In a starter 16 23
Bolts of fastening of the inlet pipeline 37 54
Axial and fixing bolts of the generator 38 51
Screws подшипникового a generator casing 2.0 5.4
Bolts of a cover of the generator 2.0 5.4
Nut of fastening of a pulley of a drive of the generator 59 98
Fastening screws диодной rectifier assemblages 2.0 5.4
Support bolt натяжителя 19 26

Diesel models

Candles накаливания 14.7 19.6
Bolts of fastening of a starter and its basic arm 37 54
Plug nut In a starter 16 23
Bolts of fastening of the generator (see an illustration)
  • AND
19 26
  • IN
38 51